InstaMix Iodine Concentrate IC

Concentrated Disinfecting Teat Dip

Aids in reducing the spread of mastitis-causing organisms

ACTIVE INGREDIENTS:

Iodine............................ 5.2%

OTHER INGREDIENTS:

Emollient* ............................ 8.5%

*From glycerin

I_²

PART A

KEEP OUT OF REACH OF CHILDREN

! CAUTION

READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING THIS PRODUCT

FIRST AID

Contact with product can cause irritation to eyes.  Avoid contact with eyes.

Eye Contact: Flush with water.

If swallowed: Do not induce vomiting.  Call a physician or poison control center immediately.

InstaMix^™ Glycolic Concentrate (Part A) is an iodine concentrate exclusively designed for use in combination with InstaMix^™ G Emollient Concentrate (Part B) for on-site blending / production of teat dips.  To be blended with a DeLaval recommended on-site blending unit.

STORAGE AND DISPOSAL

THOROUGHLY RINSE ALL MEASURING DEVICES AND STORE OUT OF REACH OF CHILDREN. Avoid contact with food or feed.  Avoid storing near heat or open flame. Keep from freezing. If product is frozen, thaw in warm room and mix well before using. Keep container tightly closed when not in use. Do not reuse empty container. Rinse empty container before disposing in a safe manner.

GENERAL INSTRUCTIONS

• Do not use full-strength.
• Consult veterinarian before starting or continuing to use teat dip if cow's teats are sore or chapped.
• Do not use teat dip for cleaning and/or sanitizing of dairy equipment.
• Discard any teat sanitizing solution that becomes dirty or contaminated for any reason.
• Good dairy practices suggest the thorough cleaning and sanitizing of teats before milking to avoid contamination and assist in the control of mastitis.
• To be mixed with InstaMix^™ G Emollient Concentrate (Part B) using a DeLaval recommended on-site blending unit.  Can be diluted to create 18 formula options.

USE DIRECTIONS

Pre-Dipping

• Remove excess organic debris and forestrip.
• Dip or spray cow's teats with properly diluted teat dip prepared with the DeLaval recommended on-site blending unit.
• Allow a 30 second contact time.
• Dry teats thoroughly with a clean, single-service paper towel.
• Attach milker unit.

Post-Dipping

• Immediately after removing the milker unit, dip or spray each teat with properly diluted teat dip prepared with a DeLaval recommended on-site blending unit.
• Before exposing cow's teats to below freezing temperatures, the teats should be thoroughly dry to reduce the potential of frostbite.  Failure to follow these instructions may result in frozen teats and injured animals.

IMPORTANT!

• 0.25% teat dip must be mixed on demand.
• 0.5% - 1.0% teat dip must be used within two weeks after mixing.
• Discard unused mixtures after above noted times.

Undiluted product may undergo an increase in viscosity when exposed to cold temperatures.  Pumps must be recalibrated in those conditions to maintain accurate dosing.  If product freezes, thaw it completely and mix properly before use.  Consult your DeLaval representative for questions on specific applications.

NET CONTENTS:        US GAL. (      L)

LOT NO.:

EXP. DATE:

Manufactured for: DeLaval, Inc.

11100 N. Congress Avenue

Kansas City, MO 64153

Phone: 816-891-7700

Manufactured by: WestAgro, Inc.,

© 2924, Made in USA

image description

Add image transcription here...